Diesel Forum Forum for Diesel engine vehicle related discussion
Sponsored by:
Sponsored by:

E320 CDi mod

Thread Tools
 
Search this Thread
 
Rating: Thread Rating: 4 votes, 4.00 average.
 
Old Jan 12, 2011 | 09:21 PM
  #301  
gaiex's Avatar
MBWorld Fanatic!
20 Year Member
 
Joined: May 2004
Posts: 1,482
Likes: 4
From: Portugal
'13 E500 Coupe AMG// '17 E350d // '24 E53 AMG
The first engine MOD in my 3.0 V6 will be removing the DPF filter, a very essencial MOD as it only makes dificult getting more power!!!

At the same time a ECU remap will be done, at first only with DPF turned off and some limiters rised up, just for start.
After some other intended engine MOD's, more power will come

Here is what is going in the place of the DPF:


Last edited by gaiex; Jan 12, 2011 at 09:25 PM.
Reply
Old Jan 17, 2011 | 08:12 AM
  #302  
190Benz's Avatar
Senior Member
 
Joined: Jan 2009
Posts: 291
Likes: 0
190 evoII replica
Nice dpf replacement!!

Where did you get that from as it doesn't look fabricated?

How is your wife's w203? I am still looking for a intercooler like the one you have on the w203 but i can't find one. :-(
Reply
Old Jan 17, 2011 | 10:29 AM
  #303  
gaiex's Avatar
MBWorld Fanatic!
20 Year Member
 
Joined: May 2004
Posts: 1,482
Likes: 4
From: Portugal
'13 E500 Coupe AMG// '17 E350d // '24 E53 AMG
Originally Posted by 190Benz
Nice dpf replacement!!

Where did you get that from as it doesn't look fabricated?

How is your wife's w203? I am still looking for a intercooler like the one you have on the w203 but i can't find one. :-(
The pipe is the OEM one from the CLK without DPF, I'm glad I didn't bought a new car, since newer ones all have DPF!

The intercooler you can get many universal ones from ebay...
Reply
Old Jan 22, 2011 | 09:52 AM
  #304  
Micah / AF1 Rac's Avatar
Senior Member
 
Joined: Jan 2011
Posts: 422
Likes: 52
From: McDade, Texas
W211 e320 CDI
I have looked around all over the net and eBay and see that the only way to remove the catalyzer from the down pipe after the turbine is apparently to remove the stock pipe and take an air chisel to the catalyzer media. Does anyone just sell an aftermarket down pipe which has nothing in it?

Is there any way to turn off EGR without doing to full re-flash right now or setting off a warning light on the dash?

I want to do several mods in a specific order and watch data streams and egt and see what difference each change makes.

BTW, the generic eBay intercooler thought is interesting, I had no idea how cheap and plentiful intercoolers were now, this is the first turbo car I have modified in a decade and a half...added to wish list.


God, it has only been 4 days without my little CDI since the GF's BMW broke again...it feels like torture to drive my NSX now...how life changes you and old age creeps up from behind!

Last edited by Micah / AF1 Rac; Jan 23, 2011 at 10:32 AM.
Reply
Old Jan 24, 2011 | 06:25 AM
  #305  
190Benz's Avatar
Senior Member
 
Joined: Jan 2009
Posts: 291
Likes: 0
190 evoII replica
Originally Posted by gaiex
The pipe is the OEM one from the CLK without DPF, I'm glad I didn't bought a new car, since newer ones all have DPF!

The intercooler you can get many universal ones from ebay...
The wife and intercooler question was for Tuikku. Sorry for the missunderstanding.


I looked at some intercoolers on the web but i am not sure what would be the biggest size that fits. And how to mount the tubes for an OEM look.
Reply
Old Feb 8, 2011 | 06:17 PM
  #306  
edd1e22's Avatar
Member
20 Year Member
 
Joined: Jul 2004
Posts: 150
Likes: 3
From: San Jose, CA
2005 G500
Hey Micah, good seeing you here. I'm on af1 as well and also getting an 06 CDI.
Reply
Old Feb 9, 2011 | 08:12 AM
  #307  
joskami's Avatar
Junior Member
15 Year Member
 
Joined: Jan 2008
Posts: 41
Likes: 0
S212 350cdi-4-matic `11 "AMG" // C207 350cdi ´10 "AMG"
Originally Posted by gaiex
The first engine MOD in my 3.0 V6 will be removing the DPF filter, a very essencial MOD as it only makes dificult getting more power!!!

At the same time a ECU remap will be done, at first only with DPF turned off and some limiters rised up, just for start.
After some other intended engine MOD's, more power will come

Here is what is going in the place of the DPF:

Do you have orginal part number that pipe?
Reply
Old Feb 9, 2011 | 08:21 AM
  #308  
gaiex's Avatar
MBWorld Fanatic!
20 Year Member
 
Joined: May 2004
Posts: 1,482
Likes: 4
From: Portugal
'13 E500 Coupe AMG// '17 E350d // '24 E53 AMG
Originally Posted by joskami
Do you have orginal part number that pipe?
There are 2 diameter available... for witch car do you want to install it?
Reply
MB World Stories

The Best of Mercedes & AMG

story-0

6 Mercedes Models That Did NOT Age Well (But Are Somehow Still Cool)

 Verdad Gallardo
story-1

Manual Mercedes? 6 Times Sindelfingen Let Drivers Have All The Fun

 Verdad Gallardo
story-2

Mercedes SLR McLaren 722 S Is Extremely Rare Example Modified by McLaren

 Verdad Gallardo
story-3

8 Classic Boxy Mercedes Designs That Have Aged Like Fine Wine

 Verdad Gallardo
story-4

Flawlessly Restored Mercedes 190E Evo II Heads to Auction

 Verdad Gallardo
story-5

Electric Mercedes C-Class Unveiled: 11 Things You Need to Know

 Verdad Gallardo
story-6

Mercedes EQS Gets A Major Update: Everything You Need to Know

 Verdad Gallardo
story-7

5 Underrated Mercedes-Benz Models That Don't Get the Love They Deserve

 Verdad Gallardo
story-8

Mercedes 300D Has Pushed Well Past 1 Million Miles and It Ain't Stopping

 Verdad Gallardo
story-9

10 Most Reliable Mercedes-Benz Models You Can Buy Used

 Verdad Gallardo
Old Feb 9, 2011 | 08:38 AM
  #309  
joskami's Avatar
Junior Member
15 Year Member
 
Joined: Jan 2008
Posts: 41
Likes: 0
S212 350cdi-4-matic `11 "AMG" // C207 350cdi ´10 "AMG"
Originally Posted by gaiex
There are 2 diameter available... for witch car do you want to install it?
S211 320cdi v6 /2007
Reply
Old Feb 9, 2011 | 08:42 AM
  #310  
gaiex's Avatar
MBWorld Fanatic!
20 Year Member
 
Joined: May 2004
Posts: 1,482
Likes: 4
From: Portugal
'13 E500 Coupe AMG// '17 E350d // '24 E53 AMG
Originally Posted by joskami
S211 320cdi v6 /2007
If you want it for the w211 it's not the same pipe, that one is only for w203/w209.
The w211 is different but I think there should be a version without DPF, so there must be a pipe also.
I could look for it but I can make a mistake. If you want it its better to ask for it in you MB dealer. Let them choose
Reply
Old Feb 12, 2011 | 01:50 PM
  #311  
kf8s's Avatar
Newbie
 
Joined: Feb 2011
Posts: 3
Likes: 0
2006 e320cdi
gutting the cat

on my 06 E320cdi i have taking evreything out from inside the cat with negative results, lost power, i have now removed and modified the cat internally 3 times to create more back pressure with very good results.
Reply
Old Feb 12, 2011 | 02:29 PM
  #312  
gaiex's Avatar
MBWorld Fanatic!
20 Year Member
 
Joined: May 2004
Posts: 1,482
Likes: 4
From: Portugal
'13 E500 Coupe AMG// '17 E350d // '24 E53 AMG
Originally Posted by kf8s
on my 06 E320cdi i have taking evreything out from inside the cat with negative results, lost power, i have now removed and modified the cat internally 3 times to create more back pressure with very good results.
Its better to remove the cat out and put a direct pipe and you keep your cat intact.
Reply
Old Feb 12, 2011 | 05:35 PM
  #313  
kf8s's Avatar
Newbie
 
Joined: Feb 2011
Posts: 3
Likes: 0
2006 e320cdi
I have done that as well same results, cut the pipe out and modified the cat internally to create back pressure, I am happy now, a rocket ship.
Reply
Old Feb 13, 2011 | 03:02 PM
  #314  
2slowcdi's Avatar
Member
 
Joined: Sep 2010
Posts: 134
Likes: 1
2006 E320 CDI 235 hp 420 ft tq
Originally Posted by kf8s
I have done that as well same results, cut the pipe out and modified the cat internally to create back pressure, I am happy now, a rocket ship.


Do you think if you had the ECU remapped ( Chipped ) it would have fixed the loss of power?
Reply
Old Feb 13, 2011 | 06:42 PM
  #315  
harkgar's Avatar
MBWorld Fanatic!
 
Joined: Apr 2006
Posts: 1,332
Likes: 4
From: Toronto
2006 E320 CDi, 2008 3/4 Ton Suburban, 2007 "rice rickshaw" Accord 5 speed
Originally Posted by kf8s
I have done that as well same results, cut the pipe out and modified the cat internally to create back pressure, I am happy now, a rocket ship.
Why would hollowing out the catalytic convertor result in power loss? The old doctrine was the less restriction there is the more power you would create.

Secondly, are you located in the USA df8s? If so, who did you use to re-chip your computer?
Reply
Old Feb 13, 2011 | 06:49 PM
  #316  
harkgar's Avatar
MBWorld Fanatic!
 
Joined: Apr 2006
Posts: 1,332
Likes: 4
From: Toronto
2006 E320 CDi, 2008 3/4 Ton Suburban, 2007 "rice rickshaw" Accord 5 speed
Originally Posted by 240D 3.0T
Um, the 3.2L CDI has more displacement per cylinder than the V8 so I doubt there will be any parts swapping gains there and the V6 is the same displacement pr cylinder.
240: from your reasoning we should be looking at MB diesels with 5 or even 4 cylinders (likely with larger individual cylinder capacity)?
Reply
Old Feb 13, 2011 | 10:38 PM
  #317  
kf8s's Avatar
Newbie
 
Joined: Feb 2011
Posts: 3
Likes: 0
2006 e320cdi
Originally Posted by harkgar
Why would hollowing out the catalytic convertor result in power loss? The old doctrine was the less restriction there is the more power you would create.

Secondly, are you located in the USA df8s? If so, who did you use to re-chip your computer?
I am located in \canada.
my car has not been chipped yet, i am trying to get as many hp as i can before the ecu tuning, i want to tune the exhaust for better performance, and i am sure after the ecu tuning will be much better,

i should have taken some photos of the work i did to the empty cat,
directly under the inlet pipe in the cat i have welded a flat plate with a ridge in order to create back pressure yet free outing the turbo must have liked the signal from the plate creating an obstacle the power as increased by a lot, i have owned this car for two years now and i know the power, not only revs freely to over 4500 but its also very responsive from 1500 and up, before dint start pulling hard until 2200 and stopped pulling at around 3800, with some leg, i whent to a flat road last knight and tried runs 0to 100 i was getting a reading around 6.3 to 6.6, i think thats pretty good for not chipping it, this cat work is unbeliavable, i thing i have found something here.
Reply
Old Feb 14, 2011 | 01:47 PM
  #318  
edd1e22's Avatar
Member
20 Year Member
 
Joined: Jul 2004
Posts: 150
Likes: 3
From: San Jose, CA
2005 G500
Can you post a pic of the mods you made to down pipe?
Reply
Old Feb 14, 2011 | 01:54 PM
  #319  
2slowcdi's Avatar
Member
 
Joined: Sep 2010
Posts: 134
Likes: 1
2006 E320 CDI 235 hp 420 ft tq
That is a 100 Kph or 62 mph yes ?
Look out M5's
Reply
Old Feb 21, 2011 | 10:17 PM
  #320  
isstay's Avatar
Senior Member
 
Joined: Mar 2009
Posts: 430
Likes: 6
From: USA, EU
06 E320 CDI (GONE), 14 Jeep GC EcoDiesel, 01 Disco II (GONE), 09 BMW X3 3.0 Si Xdrive
Originally Posted by 2slowcdi
Micah / AF1 Rac
I had my CDI ECU remapped over in Fort Worth by a Upsolute dealer , I had run their program in a VW TDI for seven years with no problems.
But the program leaves the EGR alone and the top end is still 130mph in the CDI, but I have 34 hp and 51 ft lbs tq more now.
I have found a person in the DFW area that has a person that is remapping his TDI to run a intake and turbo that he is selling.
He is pushing around 260 hp out of his 1.9L 4cly, he told that the guy that programs the ECU for him can program any mods in.
I was at a TDI get together when I talked to him. I think I almost talked him into getting his wife a CDI.
I will find his business card with his web site and post it.

His web site is driverfire.com but it under construction so I called him one programer is on the west coast and sends him his own programs and he uploads them himself so I don't know how that will work. He did not get his wife ths CDI she got a new TDI.
He is going to call and let me know what can be done as far as the top end limiter and the EGR.
I take mine out on a track every once in a while and it would be nice to have a car that was at least as fast as my old TDI was.
If you want more you will have to reprograme TCU also. In US 320 CDI trany can handle 580 Nm or 428 lbf-ft before start slipping. Inmotion web site states that they can take the EGR and speed limiter away if you want.
Reply
Old Feb 22, 2011 | 04:34 AM
  #321  
gaiex's Avatar
MBWorld Fanatic!
20 Year Member
 
Joined: May 2004
Posts: 1,482
Likes: 4
From: Portugal
'13 E500 Coupe AMG// '17 E350d // '24 E53 AMG
Originally Posted by isstay
If you want more you will have to reprograme TCU also. In US 320 CDI trany can handle 580 Nm or 428 lbf-ft before start slipping. Inmotion web site states that they can take the EGR and speed limiter away if you want.
Only 580Nm!?
I know some 270cdi with 620Nm!
Reply
Old Feb 22, 2011 | 12:50 PM
  #322  
isstay's Avatar
Senior Member
 
Joined: Mar 2009
Posts: 430
Likes: 6
From: USA, EU
06 E320 CDI (GONE), 14 Jeep GC EcoDiesel, 01 Disco II (GONE), 09 BMW X3 3.0 Si Xdrive
Originally Posted by gaiex
Only 580Nm!?
I know some 270cdi with 620Nm!
It will hold for few months from the beginning probably... but the trany designation is what is been programed into it. Maybe if you flash TCU you can raise that limit, I don’t know how they limit it. Mine has W5A580 designation in EPC Specs, so is rated to 580 Nm. Look some of the 7 speed on different cars and they all say 700 Nm.
Attached Files
File Type: pdf
Mercedes 722.6.pdf (321.5 KB, 2327 views)
Reply
Old Feb 22, 2011 | 04:32 PM
  #323  
2slowcdi's Avatar
Member
 
Joined: Sep 2010
Posts: 134
Likes: 1
2006 E320 CDI 235 hp 420 ft tq
Originally Posted by isstay
If you want more you will have to reprograme TCU also. In US 320 CDI trany can handle 580 Nm or 428 lbf-ft before start slipping. Inmotion web site states that they can take the EGR and speed limiter away if you want.

I will be looking into the Inmotion web site.

I did not know about the transmission needing to be reprogramed but it makes sense.

Thank You for the Info !
Reply
Old Feb 22, 2011 | 04:58 PM
  #324  
gaiex's Avatar
MBWorld Fanatic!
20 Year Member
 
Joined: May 2004
Posts: 1,482
Likes: 4
From: Portugal
'13 E500 Coupe AMG// '17 E350d // '24 E53 AMG
Originally Posted by isstay
It will hold for few months from the beginning probably... but the trany designation is what is been programed into it. Maybe if you flash TCU you can raise that limit, I don’t know how they limit it. Mine has W5A580 designation in EPC Specs, so is rated to 580 Nm. Look some of the 7 speed on different cars and they all say 700 Nm.
The car I know had zero transmission problems for the last 2 years!
Reply
Old Feb 23, 2011 | 10:03 AM
  #325  
isstay's Avatar
Senior Member
 
Joined: Mar 2009
Posts: 430
Likes: 6
From: USA, EU
06 E320 CDI (GONE), 14 Jeep GC EcoDiesel, 01 Disco II (GONE), 09 BMW X3 3.0 Si Xdrive
Originally Posted by gaiex
The car I know had zero transmission problems for the last 2 years!
Is it 5 or 7 speed?
Maybe tuikku can clarify this?

Last edited by isstay; Feb 23, 2011 at 10:07 AM.
Reply


You have already rated this thread Rating: Thread Rating: 4 votes, 4.00 average.


All times are GMT -4. The time now is 12:14 AM.

story-0
6 Mercedes Models That Did NOT Age Well (But Are Somehow Still Cool)

Slideshow: Not every Mercedes design becomes timeless, some feel stuck in the era they came from.

By Verdad Gallardo | 2026-05-12 18:09:07


VIEW MORE
story-1
Manual Mercedes? 6 Times Sindelfingen Let Drivers Have All The Fun

Slideshow: Yes, Mercedes built manual cars, and some of them are far more interesting than you'd expect.

By Verdad Gallardo | 2026-05-02 12:36:58


VIEW MORE
story-2
Mercedes SLR McLaren 722 S Is Extremely Rare Example Modified by McLaren

Slideshow: A one-of-one U.S.-spec Mercedes-Benz SLR McLaren Roadster became even rarer after a factory-backed transformation at McLaren's headquarters.

By Verdad Gallardo | 2026-04-29 11:19:28


VIEW MORE
story-3
8 Classic Boxy Mercedes Designs That Have Aged Like Fine Wine

Slideshow: Before curves took over, Mercedes mastered the art of the straight line, and some of those shapes still look right today.

By Verdad Gallardo | 2026-04-25 12:05:49


VIEW MORE
story-4
Flawlessly Restored Mercedes 190E Evo II Heads to Auction

Slideshow: The 190E Evolution II shows how a homologation necessity became a six-figure collector icon.

By Verdad Gallardo | 2026-04-22 17:53:47


VIEW MORE
story-5
Electric Mercedes C-Class Unveiled: 11 Things You Need to Know

Slideshow: Mercedes is turning one of its core nameplates electric, and the details show just how serious this shift is.

By Verdad Gallardo | 2026-04-21 13:58:06


VIEW MORE
story-6
Mercedes EQS Gets A Major Update: Everything You Need to Know

Slideshow: Faster charging, longer range, and a controversial steer-by-wire system define the latest evolution of Mercedes-Benz EQS.

By Verdad Gallardo | 2026-04-15 10:35:34


VIEW MORE
story-7
5 Underrated Mercedes-Benz Models That Don't Get the Love They Deserve

Slideshow: These overlooked Mercedes-Benz models never got the spotlight, but they quietly delivered more than most remember.

By Verdad Gallardo | 2026-04-13 19:35:45


VIEW MORE
story-8
Mercedes 300D Has Pushed Well Past 1 Million Miles and It Ain't Stopping

Slideshow: A well-used 1991 Mercedes-Benz 300D with more than one million miles is now looking for a new owner, and it still appears ready for more.

By Verdad Gallardo | 2026-04-10 10:05:15


VIEW MORE
story-9
10 Most Reliable Mercedes-Benz Models You Can Buy Used

Slideshow: From bulletproof sedans to surprisingly tough SUVs, these Mercedes models proved that the three-pointed star can go the distance.

By Verdad Gallardo | 2026-04-08 09:55:49


VIEW MORE