ESP lights comes on Loss of power
06-11-2016, 10:03 PM
#26
Banned
Well there you go.LOL.
Anything else you want to ad anything before I start calling. I know this one big place Dealership that I have a very good rapport with and know this one Mechanic well.
Now I want to get into some drinking so **** off and I will too.
Just joking about the **** off part.
Luck.
06-11-2016, 11:35 PM
#28
MBWorld Fanatic!
I used to have something similar happen if I floored the car it would go into limp mode until I restarted it. Changing the throttle position sensor fixed it. I never got any esp light that i remember. I got the part from a junk yard for a few dollars, its the same part on lots of mercs.
06-17-2016, 07:44 PM
#30
Member
Thread Starter
Join Date: May 2016
Posts: 81
Likes: 0
Received 0 Likes
on
0 Posts
mercedes w210 e55 amg
hi guys its me AGAIN lol
right im still trying to figure out my ESP issue on the gearbox etc i checked the gearbox that i was supplied by the independent Mercedes specialist breakers and i find out my original gearbox part number was 722636 and the box they supplied is 722623.. would that cause the problem? i found out that the box they supplied belongs to a e430 V8 not an e55 amg.. its a straight fit but i think my car will struggle to work with the electronics on the new box.. what you guys think?
right im still trying to figure out my ESP issue on the gearbox etc i checked the gearbox that i was supplied by the independent Mercedes specialist breakers and i find out my original gearbox part number was 722636 and the box they supplied is 722623.. would that cause the problem? i found out that the box they supplied belongs to a e430 V8 not an e55 amg.. its a straight fit but i think my car will struggle to work with the electronics on the new box.. what you guys think?
06-18-2016, 04:26 AM
#31
new gearbox is not the correct tranny for your car, it won't hold tourqe from engine
it's for a lesser model maybe e430 like you said.
go back to shop and file a complaint getting the wrong box
if they don't replace your tranny coz they put the wrong box tell them you will report them to consumers bureau, you have consumer rights and warranty if you bought it from a shop!
it's for a lesser model maybe e430 like you said.
go back to shop and file a complaint getting the wrong box
if they don't replace your tranny coz they put the wrong box tell them you will report them to consumers bureau, you have consumer rights and warranty if you bought it from a shop!
06-18-2016, 05:07 AM
#32
MBWorld Fanatic!
Join Date: Aug 2006
Location: A.D., U.A.E
Posts: 7,002
Likes: 0
Received 377 Likes
on
342 Posts
00 C200 & 00 C55 & 06 SLK55
Dennis,
"W208 Clk430/W210 E430" sharing the same out-put power with all N/A (M119's/M113's), which is "A580Nm",
i put E430 gearbox on "1997 W210 E60" & "2000 R129 SL500", 4 years ago,,
no any issues with both cars till now..!
ZAYED,,
"W208 Clk430/W210 E430" sharing the same out-put power with all N/A (M119's/M113's), which is "A580Nm",
i put E430 gearbox on "1997 W210 E60" & "2000 R129 SL500", 4 years ago,,
no any issues with both cars till now..!
ZAYED,,
06-18-2016, 06:41 AM
#34
MBWorld Fanatic!
Join Date: Aug 2006
Location: A.D., U.A.E
Posts: 7,002
Likes: 0
Received 377 Likes
on
342 Posts
00 C200 & 00 C55 & 06 SLK55
No need to change the gearbox TCU, you have to use your Exist one, to match with our Vin. & diff. Ratio,
maybe something wrong with speed sensor in "conductor plate"..!,,
i prefer to diagnose the car via "STAR/SDS", to make sure what Exactly happened to the Electrical side of the gearbox..!!
ZAYED,,
maybe something wrong with speed sensor in "conductor plate"..!,,
i prefer to diagnose the car via "STAR/SDS", to make sure what Exactly happened to the Electrical side of the gearbox..!!
ZAYED,,
06-21-2016, 06:44 AM
#36
Senior Member
The CAN Errors can surely be ignored ... regarding your pictures you have Communicationerror with UBF and PSE
UBF means "Unteres Bedienfeld" ... translated in english it would bei "lower control panel" and this means the buttons around the shifter (not the shifter!)
PSE means "Pneumatische Steuereinheit" ... translated it is pneumatic control unit ... it is the controlunit for the Alarmsystem and the doorlocks.
Probably both where disconnected a while ago?
As Zayed says, check with StarDiagnoses and ERASE all error, do a testdrive and read again, then post the NEW errors.
Regarding to your picture i only see
"Safety Fuel Shut off" and "Faul in DAS to Engine Control Module" as possible source of your power loss ... first should be the Tank pressure sensor, the 2nd one i never saw before, i am sure reading errors with StarDiagnoses would give a more explicit discription.
greetings, Fabian
UBF means "Unteres Bedienfeld" ... translated in english it would bei "lower control panel" and this means the buttons around the shifter (not the shifter!)
PSE means "Pneumatische Steuereinheit" ... translated it is pneumatic control unit ... it is the controlunit for the Alarmsystem and the doorlocks.
Probably both where disconnected a while ago?
As Zayed says, check with StarDiagnoses and ERASE all error, do a testdrive and read again, then post the NEW errors.
Regarding to your picture i only see
"Safety Fuel Shut off" and "Faul in DAS to Engine Control Module" as possible source of your power loss ... first should be the Tank pressure sensor, the 2nd one i never saw before, i am sure reading errors with StarDiagnoses would give a more explicit discription.
greetings, Fabian
,,
07-02-2016, 05:44 PM
#40
Member
Thread Starter
Join Date: May 2016
Posts: 81
Likes: 0
Received 0 Likes
on
0 Posts
mercedes w210 e55 amg
well ill tell you, my gearbox was faulty so i replaced it with a e430 box which was a straight fit no issues there but the main problem was the gearbox dipstick pipe it was very close to the throttle lever and wouldnt let it open up as the lever was hitting the pipe.. i pushed the pipe to give the throttle lever space to move and there it was the fault solved, took it to 2 different merc specialist and couldnt solve the issue they said ESP unit and throttle valve actuator which lead me to this.. im so chuffed, for the first time i felt the full power of the V8 and felt.... simply AMAZING hehe...
?!?!?!?
07-02-2016, 08:57 PM
#42
Member
Thread Starter
Join Date: May 2016
Posts: 81
Likes: 0
Received 0 Likes
on
0 Posts
mercedes w210 e55 amg
hehe im chuffed.. i want to thank your guys for the help you offered me it was a very complicated subject but you helped me stay calm and offered me comfort.. thats priceless
07-03-2016, 08:04 AM
#43
Senior Member
Great! Happy to hear you solved it ... but:
I really dont get it...
What throttle lever? The E55 has a electronical throttle body?
greetings, fabian
I really dont get it...
What throttle lever? The E55 has a electronical throttle body?
greetings, fabian
07-03-2016, 08:25 AM
#44
Member
Thread Starter
Join Date: May 2016
Posts: 81
Likes: 0
Received 0 Likes
on
0 Posts
mercedes w210 e55 amg
hi mate, thats what i thought but mine has a plastic lever "thing" connected to the throttle body so when my throttle flap opens the plastic lever thing turns with it
