MBUSA W221 Bulletins to date
#126
Out Of Control!!
Thread Starter
Join Date: Jul 2003
Location: North Scottsdale, AZ
Posts: 15,903
Received 4,435 Likes
on
3,152 Posts
'71 Pinto
Recalls & Service Campaigns are covered out of warranty at no cost to owner in addition some DTBs "may" qualify for goodwill assistance out of warranty ranging from substantial discounting to no out of pocket cost if a production range is documented (i.e.: VIN , engine # etc. range) and vehicle has a service history with any MB dealership.
#127
Senior Member
Join Date: Jun 2004
Location: LI, NY
Posts: 382
Likes: 0
Received 2 Likes
on
2 Posts
(1960) 300d, S550 AMG S500 S600 560SEL
Recalls & Service Campaigns are covered out of warranty at no cost to owner in addition some DTBs "may" qualify for goodwill assistance out of warranty ranging from substantial discounting to no out of pocket cost if a production range is documented (i.e.: VIN , engine # etc. range) and vehicle has a service history with any MB dealership.
#128
Senior Member
Join Date: Oct 2008
Location: Houston, TX
Posts: 420
Likes: 0
Received 3 Likes
on
3 Posts
2002 Mercedes S 430(GONE), 2001 E320(GONE), 2007 S550(GONE), 2009 BMW X6(GONE), 2014 S550
Recalls & Service Campaigns are covered out of warranty at no cost to owner in addition some DTBs "may" qualify for goodwill assistance out of warranty ranging from substantial discounting to no out of pocket cost if a production range is documented (i.e.: VIN , engine # etc. range) and vehicle has a service history with any MB dealership.
#129
Out Of Control!!
Thread Starter
Join Date: Jul 2003
Location: North Scottsdale, AZ
Posts: 15,903
Received 4,435 Likes
on
3,152 Posts
'71 Pinto
Service Campaign 2011110013 DEC11 - MY10-12 221 fatigue of high voltage fuse may occur dealer will update high voltage battery software. Approximately 1858 vehicles affected.
Service Campaign 2011120005 DEC11 - MY12 221 electronic ignition switch may have been damaged during production dealer will replace. Approximately 5 vehicles affected.
Service Campaign 2011120005 DEC11 - MY12 221 electronic ignition switch may have been damaged during production dealer will replace. Approximately 5 vehicles affected.
#130
Out Of Control!!
Thread Starter
Join Date: Jul 2003
Location: North Scottsdale, AZ
Posts: 15,903
Received 4,435 Likes
on
3,152 Posts
'71 Pinto
Recall 2011110002 JAN12 – 2012 221, check diesel fuel filter replace if necessary. Due to the variations in the materials used by supplier filter may develop leaks. Approximately 6,784 vehicles affected.
Service Campaign 2012010003 JAN12 - 2010 216 & 221 instrument cluster software, communication issues may occur dealer will update.
Service Campaign 2012010003 JAN12 - 2010 216 & 221 instrument cluster software, communication issues may occur dealer will update.
#131
Senior Member
Join Date: Jun 2004
Location: LI, NY
Posts: 382
Likes: 0
Received 2 Likes
on
2 Posts
(1960) 300d, S550 AMG S500 S600 560SEL
Recall 2011110002 JAN12 – 2012 221, check diesel fuel filter replace if necessary. Due to the variations in the materials used by supplier filter may develop leaks. Approximately 6,784 vehicles affected.
Service Campaign 2012010003 JAN12 - 2010 216 & 221 instrument cluster software, communication issues may occur dealer will update.
Service Campaign 2012010003 JAN12 - 2010 216 & 221 instrument cluster software, communication issues may occur dealer will update.
#132
Senior Member
Join Date: Nov 2008
Location: Florida
Posts: 250
Likes: 0
Received 0 Likes
on
0 Posts
07' 911 Turbo, 09 ML63
is mine affected
VIN: WDDNG71X47A147356
VIN: WDDNG71X47A147356
#133
Senior Member
Join Date: Jun 2004
Location: LI, NY
Posts: 382
Likes: 0
Received 2 Likes
on
2 Posts
(1960) 300d, S550 AMG S500 S600 560SEL
Recall 2011110002 JAN12 – 2012 221, check diesel fuel filter replace if necessary. Due to the variations in the materials used by supplier filter may develop leaks. Approximately 6,784 vehicles affected.
Service Campaign 2012010003 JAN12 - 2010 216 & 221 instrument cluster software, communication issues may occur dealer will update.
Service Campaign 2012010003 JAN12 - 2010 216 & 221 instrument cluster software, communication issues may occur dealer will update.
#134
Senior Member
Join Date: Nov 2008
Location: Florida
Posts: 250
Likes: 0
Received 0 Likes
on
0 Posts
07' 911 Turbo, 09 ML63
my VIN: WDDNG71X47A147356
is any of above bulletin will affect me?
is any of above bulletin will affect me?
#135
Out Of Control!!
Thread Starter
Join Date: Jul 2003
Location: North Scottsdale, AZ
Posts: 15,903
Received 4,435 Likes
on
3,152 Posts
'71 Pinto
my VIN: WDDNG71X47A147356 is any of above bulletin will affect me?
#136
Out Of Control!!
Thread Starter
Join Date: Jul 2003
Location: North Scottsdale, AZ
Posts: 15,903
Received 4,435 Likes
on
3,152 Posts
'71 Pinto
Service Campaign 2012010006 MAR12 – MY11-12 221 dealer will update tire pressure monitoring control unit, 4762 vehicles affected.
Service Campaign 2012020001 MAR12 – MY12 166, 221diesel may not meet OBD specifications dealer will update engine control module software. 1978 vehicles affected.
Service Campaign 2012020001 MAR12 – MY12 166, 221diesel may not meet OBD specifications dealer will update engine control module software. 1978 vehicles affected.
#137
P-B-83.10/108 JAN08 Water leakage into the passenger compartment may cause erroneous blower and A/C operation. CL (216) caused by blocked drain holes on the right and/or left sidewalls. S-Class (221) due to body tolerances, the left rear or right rear wheelhouse may leak. Moisture can penetrate the rocker panel on one and/or both sides. If the4 drain grommets do not open when moisture enters the rocker panel, moisture can enter the passenger compartment. The result of which is that control units, electrical connectors, and lines become damp. Have your dealer check your VIN in VMI to determine if your vehicle is involved in Service Campaigns 2008010002 and/or 2006020007 if not, then this DTB will apply.
S-B-46.30/21a FEB08 Grinding or gushing noises heard from the area of the steering system/power steering pump may be in the A/C compressor drive. Noise is present at both idle and higher engine speeds, can be heard whether the steering wheel is stationary or moving, and frequency increases with the engine speed.
S-B-46.30/21a FEB08 Grinding or gushing noises heard from the area of the steering system/power steering pump may be in the A/C compressor drive. Noise is present at both idle and higher engine speeds, can be heard whether the steering wheel is stationary or moving, and frequency increases with the engine speed.
#138
Out Of Control!!
Thread Starter
Join Date: Jul 2003
Location: North Scottsdale, AZ
Posts: 15,903
Received 4,435 Likes
on
3,152 Posts
'71 Pinto
LI00.90-P-050323 – 221 except 4MATIC, steering wheel vibrations/shimmy @ highway speeds. Vibration caused by wheel/tire balance/uniformity; torque strut bushing; or steering rack (vehicles with EHPS up to VIN A351230)
#141
Out Of Control!!
Thread Starter
Join Date: Jul 2003
Location: North Scottsdale, AZ
Posts: 15,903
Received 4,435 Likes
on
3,152 Posts
'71 Pinto
Supersedes DTB P-B-91.25/169a
221.171/176/177/179/186 MY07 – VIN range A106647 to A134746
216.371/376/377/379/386 – A002723 to A006715
Multi-contour/Dynamic Seat air cushions not inflating or bubble formation. Cause inoperative transistors in the valve electronics depending on DTC replace corresponding unit i.e. backrest or cushion module, massage pad, etc.
221.171/176/177/179/186 MY07 – VIN range A106647 to A134746
216.371/376/377/379/386 – A002723 to A006715
Multi-contour/Dynamic Seat air cushions not inflating or bubble formation. Cause inoperative transistors in the valve electronics depending on DTC replace corresponding unit i.e. backrest or cushion module, massage pad, etc.
#142
Out Of Control!!
Thread Starter
Join Date: Jul 2003
Location: North Scottsdale, AZ
Posts: 15,903
Received 4,435 Likes
on
3,152 Posts
'71 Pinto
#143
Out Of Control!!
Thread Starter
Join Date: Jul 2003
Location: North Scottsdale, AZ
Posts: 15,903
Received 4,435 Likes
on
3,152 Posts
'71 Pinto
Service Campaign 2012070002 SEPT12
Models 164, 171, 203, 204, 207, 209, 211, 212, 216, 219, 221, 230, 251, 463
Engines 272 and 273, MY 2005 – 2011 Camshaft Adjustment Solenoids - due to the settling properties of the seal, oil may leak from the camshaft adjustment solenoid dealers will retrofit four adapter harnesses onto the engine wiring harness. Covers any/all repairs due to damage from oil leak however, notes replacement of leaking camshaft solenoid is not permitted under consequential damage.
Approximately 557,108 vehicles are affected. Have dealer check VMI to determine if vehicle is included. Service Campaigns are covered out of warranty.
Models 164, 171, 203, 204, 207, 209, 211, 212, 216, 219, 221, 230, 251, 463
Engines 272 and 273, MY 2005 – 2011 Camshaft Adjustment Solenoids - due to the settling properties of the seal, oil may leak from the camshaft adjustment solenoid dealers will retrofit four adapter harnesses onto the engine wiring harness. Covers any/all repairs due to damage from oil leak however, notes replacement of leaking camshaft solenoid is not permitted under consequential damage.
Approximately 557,108 vehicles are affected. Have dealer check VMI to determine if vehicle is included. Service Campaigns are covered out of warranty.
#144
Out Of Control!!
Thread Starter
Join Date: Jul 2003
Location: North Scottsdale, AZ
Posts: 15,903
Received 4,435 Likes
on
3,152 Posts
'71 Pinto
LI54.10-P-054690 – 221095/195 (Hybrid) vehicle sporadically fails to start or can no longer be started, update electric motor control unit software.
LI54.10-P-054713 – 221.095/195 (Hybrid) IC battery fault message vehicle no longer starts, replace HV battery.
LI46.30-P-054912 – 221 VIN A286000–A495000, 216 A023500–A030800 (all without Active Body Control 489) oil leak at power supply connector of electrohydraulic power steering pump (EHPS) sometimes with reduced power assistance, replace EHPS / wiring harness / front prefuse box (depending on oil penetration)
LI54.10-P-054713 – 221.095/195 (Hybrid) IC battery fault message vehicle no longer starts, replace HV battery.
LI46.30-P-054912 – 221 VIN A286000–A495000, 216 A023500–A030800 (all without Active Body Control 489) oil leak at power supply connector of electrohydraulic power steering pump (EHPS) sometimes with reduced power assistance, replace EHPS / wiring harness / front prefuse box (depending on oil penetration)
#145
Out Of Control!!
Thread Starter
Join Date: Jul 2003
Location: North Scottsdale, AZ
Posts: 15,903
Received 4,435 Likes
on
3,152 Posts
'71 Pinto
Service Campaign 2012080004 – MY10-12 S400 Hybrid dealer will update software or if need be replace Power Electronics Module.
LI68.20-P-054982 – 221 VIN A484558 to A491452 stowage compartment/ashtray (center console) clattering noise on rough roads, felt will be installed.
LI68.20-P-054982 – 221 VIN A484558 to A491452 stowage compartment/ashtray (center console) clattering noise on rough roads, felt will be installed.
#146
Super Member
Service Campaign 2012080004 – MY10-12 S400 Hybrid dealer will update software or if need be replace Power Electronics Module.
LI68.20-P-054982 – 221 VIN A484558 to A491452 stowage compartment/ashtray (center console) clattering noise on rough roads, felt will be installed.
LI68.20-P-054982 – 221 VIN A484558 to A491452 stowage compartment/ashtray (center console) clattering noise on rough roads, felt will be installed.
#147
Out Of Control!!
Thread Starter
Join Date: Jul 2003
Location: North Scottsdale, AZ
Posts: 15,903
Received 4,435 Likes
on
3,152 Posts
'71 Pinto
#150
Out Of Control!!
Thread Starter
Join Date: Jul 2003
Location: North Scottsdale, AZ
Posts: 15,903
Received 4,435 Likes
on
3,152 Posts
'71 Pinto
Recall 2013020002 FEB13 – X204, 204, 207, 212, 216, 221 model years 2011-2012 due to issues during molding process of supplier operating pressure & high operating temperatures may result in fuel leakage. Dealer will replace fuel filter. Approximately 5,773 vehicles affected – owners of affected vehicles will receive a letter, or you can have dealer check VMI to see if vehicle is involved.