Fuel gauge issues
Thread Starter
Member
Joined: Jun 2015
Posts: 129
Likes: 5
From: Ohio
2001 E55 AMG
Fuel gauge issues
If I fill fuel to full, my initial1/4 reads 21 gallons, distance 265ish. If I drive the first quarter tank, I get the low fuel light flash, sometimes the check engine light with 0455 gross leak. I clear code and it does not return the rest of that fill up. I then check distance to empty and it will read 300-325 guesstimate until empty.
I have cleaned fuel cap and even flipped gasket. It doesn't look worn looks decent.
I have had this issue since buying the car back in June 2015. Previous owner claimed the same issue.
I recently installed a new fuel filter to help the system out but no change. Didn't figure it would help but I knew it wouldn't hurt.
Yes, I am sure it isn't the fuel gauge at fault.
I have cleaned fuel cap and even flipped gasket. It doesn't look worn looks decent.
I have had this issue since buying the car back in June 2015. Previous owner claimed the same issue.
I recently installed a new fuel filter to help the system out but no change. Didn't figure it would help but I knew it wouldn't hurt.
Yes, I am sure it isn't the fuel gauge at fault.
MBWorld Fanatic!
Joined: Nov 2008
Posts: 1,560
Likes: 10
210 55
Fuel gauge SENDER unit in this cars some time fail and produce this issue. I replace it a lot in the shop with this fail in the 00+. But please check all the purge system hoses first before replace the sender unit. maybe you have some one cracked. and check too if the purge valve (under hood, driver side with some white letters MOT). check with the engine running if you hear some ticking noise from it. if you hear it they are good, if not maybe its died
Fabio Daniel
Fabio Daniel
Thread Starter
Member
Joined: Jun 2015
Posts: 129
Likes: 5
From: Ohio
2001 E55 AMG
Fuel gauge SENDER unit in this cars some time fail and produce this issue. I replace it a lot in the shop with this fail in the 00+. But please check all the purge system hoses first before replace the sender unit. maybe you have some one cracked. and check too if the purge valve (under hood, driver side with some white letters MOT). check with the engine running if you hear some ticking noise from it. if you hear it they are good, if not maybe its died
Fabio Daniel
Fabio Daniel
