C-Class (W203) 2001-2007, C160, C180, C200, C220, C230, C240, C270, C280, C300, C320, C230K, C350, Coupe

C-Coupe HATCH won't open

Old Mar 20, 2009 | 12:10 PM
  #1  
kenx23's Avatar
Thread Starter
Newbie
 
Joined: Mar 2009
Posts: 4
Likes: 0
2003 C230 Sport Coupe
C-Coupe HATCH won't open

My trunk will not open, from the outside. I can press the emergency green button on the inside of the trunk and it will open. I am not sure how to fix this. Please help!!
Reply
Old Mar 20, 2009 | 04:30 PM
  #2  
C230 Sport Coup's Avatar
MBWorld Fanatic!
20 Year Member
Liked
Loved
Community Favorite
 
Joined: Jun 2002
Posts: 7,267
Likes: 170
From: So. Oregon Coast
C230 Sport Coup + 2006 W164 ML350 + 99 Ford Escort RIP
This was posted on another site...but without pics and apparently is a fairly common issue, and can be fixed DIY.
I'm going to kill 2 birds with one stone, fix the hatch issue, and
fix all the squeaks and creaks from the plastic pieces I'll be removing to get to the hatch
switch.
So, if you can wait well, might be up to a week, since I'm sick and not feeling so well, and I need to pick up an SD card, since I lost mine but...

I'll post a DIY with pics.
The short answer is apparently the micro switch in the hatch either gets
pushed out of position or goes bad, and supposedly the micro switch can be had for 17 bucks according to someone who didn't bother to post the pn.

I hate it when people post helpful info and leave out the most critical info...
arrgh.

Meanwhile try doing what I do, which is pull on the hatch latch strongly while at the same time
flashing the open function on the key. Sometimes it takes 10 times but it eventually opens.

Keep constant pressure on the latch, it's a matter of getting it to make contact.

Last edited by C230 Sport Coup; Mar 20, 2009 at 04:33 PM.
Reply
Old Mar 20, 2009 | 08:04 PM
  #3  
UK-C200's Avatar
Super Member
 
Joined: Nov 2007
Posts: 529
Likes: 0
From: London, GB
RHD C200 Sport Coupe, RHD SLK-55, LHD SLK-350
hey - it's one of these two parts I think -

A2038217551 (90 degree, marked as "US")
A2038217451

Take a picture of yours - I'll try and match it to the diagrams..
Reply
Old Mar 20, 2009 | 10:24 PM
  #4  
C230Brit's Avatar
Senior Member
15 Year Member
 
Joined: Oct 2007
Posts: 387
Likes: 4
From: Boston, MA
2010 E550 Coupe
Funny, I was getting round to posting about this too. I've noticed the trunk has been harder to unlatch of late. I considered it being down to cold weather causing some kind of interference with the mechanism...I've had to resort to using the latch on the (3 button) remote/key.

Secondly, does anyone know of better trunk arms to allow the trunk to lift up fully rather than just lifting approx 2 inches. I've been impressed my friend in the UK how's BMW coupe is of similar design - and the trunk arms are really powerful, lifting the trunk open fully.

I assume the stock MB spring arms are not designed to lift the trunk fully? Shame...
Reply
Old Mar 21, 2009 | 03:42 AM
  #5  
spyderpig's Avatar
Senior Member
 
Joined: Sep 2007
Posts: 399
Likes: 0
From: NorCal
'02 CL203 M111
Can that be just a rusty fuse or one about to snap?
Reply
Old Mar 22, 2009 | 09:11 PM
  #6  
C230Brit's Avatar
Senior Member
15 Year Member
 
Joined: Oct 2007
Posts: 387
Likes: 4
From: Boston, MA
2010 E550 Coupe
Originally Posted by C230Brit
Funny, I was getting round to posting about this too. I've noticed the trunk has been harder to unlatch of late. I considered it being down to cold weather causing some kind of interference with the mechanism...I've had to resort to using the latch on the (3 button) remote/key.

Secondly, does anyone know of better trunk arms to allow the trunk to lift up fully rather than just lifting approx 2 inches. I've been impressed my friend in the UK how's BMW coupe is of similar design - and the trunk arms are really powerful, lifting the trunk open fully.

I assume the stock MB spring arms are not designed to lift the trunk fully? Shame...

These are what I am after

http://www.autopartswarehouse.com/se...294964807+9321

Not sure if they fit the coupe though...google "w203 Trunk strut"
Reply
Old Mar 23, 2009 | 10:33 AM
  #7  
kenx23's Avatar
Thread Starter
Newbie
 
Joined: Mar 2009
Posts: 4
Likes: 0
2003 C230 Sport Coupe
Originally Posted by C230 Sport Coup
This was posted on another site...but without pics and apparently is a fairly common issue, and can be fixed DIY.
I'm going to kill 2 birds with one stone, fix the hatch issue, and
fix all the squeaks and creaks from the plastic pieces I'll be removing to get to the hatch
switch.
So, if you can wait well, might be up to a week, since I'm sick and not feeling so well, and I need to pick up an SD card, since I lost mine but...

I'll post a DIY with pics.
The short answer is apparently the micro switch in the hatch either gets
pushed out of position or goes bad, and supposedly the micro switch can be had for 17 bucks according to someone who didn't bother to post the pn.

I hate it when people post helpful info and leave out the most critical info...
arrgh.

Meanwhile try doing what I do, which is pull on the hatch latch strongly while at the same time
flashing the open function on the key. Sometimes it takes 10 times but it eventually opens.

Keep constant pressure on the latch, it's a matter of getting it to make contact.
I can wait, the trunk has not been working for a few weeks now, so a couple more weeks won't kill me. I have already taken it to the stealership and they stated it was some type of switch. However they wanted $400.00 to fix something I am sure I am totally capble of doing myself. I'm not surprized they wanted $250.00 to replace a thermostate, that took me 10mins and $20.00.
Reply
Old Mar 24, 2009 | 05:28 AM
  #8  
C230 Sport Coup's Avatar
MBWorld Fanatic!
20 Year Member
Liked
Loved
Community Favorite
 
Joined: Jun 2002
Posts: 7,267
Likes: 170
From: So. Oregon Coast
C230 Sport Coup + 2006 W164 ML350 + 99 Ford Escort RIP
I've been down with the flu....I'll post when I'm able,
once the work is done.
Reply
MB World Stories

The Best of Mercedes & AMG

story-0

7 Craziest Things AMG Gas Ever Built

 Verdad Gallardo
story-1

New Electric Mercedes-AMG GT 4-Door Coupe Unveiled: 10 Things You Need to Know

 Verdad Gallardo
story-2

6 Mercedes Models That Did NOT Age Well (But Are Somehow Still Cool)

 Verdad Gallardo
story-3

Manual Mercedes? 6 Times Sindelfingen Let Drivers Have All The Fun

 Verdad Gallardo
story-4

Mercedes SLR McLaren 722 S Is Extremely Rare Example Modified by McLaren

 Verdad Gallardo
story-5

8 Classic Boxy Mercedes Designs That Have Aged Like Fine Wine

 Verdad Gallardo
story-6

Flawlessly Restored Mercedes 190E Evo II Heads to Auction

 Verdad Gallardo
story-7

Electric Mercedes C-Class Unveiled: 11 Things You Need to Know

 Verdad Gallardo
story-8

Mercedes EQS Gets A Major Update: Everything You Need to Know

 Verdad Gallardo
story-9

5 Underrated Mercedes-Benz Models That Don't Get the Love They Deserve

 Verdad Gallardo
Old Apr 15, 2009 | 05:21 PM
  #9  
eddieo45's Avatar
MBWorld Fanatic!
20 Year Member
Liked
Loved
Community Favorite
 
Joined: Feb 2004
Posts: 3,125
Likes: 223
From: Milton/Westport, MA USA
me: 2015 SL400 & 2015 ML400; wife: 2022 GLC Coupe; daughter: 2017 GLC SUV
anyone know how to manually lock the hatch? my smartkeys aren't working, and I'm going away tomorrow. I've locked the doors manually, but the hatch remains unlocked no matter what I do with the metal key (it turns both ways, but neither seems to lock it).
Reply
Old May 12, 2009 | 07:22 PM
  #10  
Darkman's Avatar
Junior Member
 
Joined: Nov 2001
Posts: 61
Likes: 0
2003 C240 4MATIC
Originally Posted by C230 Sport Coup
This was posted on another site...but without pics and apparently is a fairly common issue, and can be fixed DIY.
I'm going to kill 2 birds with one stone, fix the hatch issue, and
fix all the squeaks and creaks from the plastic pieces I'll be removing to get to the hatch
switch.
So, if you can wait well, might be up to a week, since I'm sick and not feeling so well, and I need to pick up an SD card, since I lost mine but...

I'll post a DIY with pics.
The short answer is apparently the micro switch in the hatch either gets
pushed out of position or goes bad, and supposedly the micro switch can be had for 17 bucks according to someone who didn't bother to post the pn.

I hate it when people post helpful info and leave out the most critical info...
arrgh.

Meanwhile try doing what I do, which is pull on the hatch latch strongly while at the same time
flashing the open function on the key. Sometimes it takes 10 times but it eventually opens.

Keep constant pressure on the latch, it's a matter of getting it to make contact.
My trunk stopped opening today. It makes a bzzz sound when I press the trunk release button on my driver's door.

How's the DIY guide going? Can you send me a link to the other site's DIY guide with no pics?
Reply
Old May 13, 2009 | 01:06 PM
  #11  
C230 Sport Coup's Avatar
MBWorld Fanatic!
20 Year Member
Liked
Loved
Community Favorite
 
Joined: Jun 2002
Posts: 7,267
Likes: 170
From: So. Oregon Coast
C230 Sport Coup + 2006 W164 ML350 + 99 Ford Escort RIP
Yeh, sorry I never got around to this...
worst case senario, pull the metal blade key from the plastic
key, bend over and look up at the hatch from below, you will see a place to
put the key, and you can open that way.
Turn, and pull up on the hatch.

Here's a thread on benzworld, apparently the switch inside the hatch is the issue.
http://www.benzworld.org/forums/w203...runk-door.html

Then see attached, I pulled some info from the service DVD as to disassembling the hatch.
While you're at it, get some adhesive felt, and stick it on the back of the plastic pieces in the hatch to quiet things down. I got it at a lighting store. Think bottom of a lamp, or online.

So, this should pretty well cover it all...
let me know how it goes.

Darkman, sounds like you have a sedan? Please update your profile to show what car you have and the area you live.
Attached Files
File Type: pdf
hatch handle.pdf (75.6 KB, 1911 views)
File Type: pdf
R$R hatch handle.pdf (100.3 KB, 1337 views)
File Type: pdf
Remove hatch panelling.pdf (91.9 KB, 1222 views)
File Type: pdf
Undo hatch panels.pdf (105.7 KB, 1447 views)

Last edited by C230 Sport Coup; May 13, 2009 at 01:24 PM.
Reply
Old May 13, 2009 | 01:44 PM
  #12  
C230 Sport Coup's Avatar
MBWorld Fanatic!
20 Year Member
Liked
Loved
Community Favorite
 
Joined: Jun 2002
Posts: 7,267
Likes: 170
From: So. Oregon Coast
C230 Sport Coup + 2006 W164 ML350 + 99 Ford Escort RIP
Here's the pic from the EPC.
#40 looks like it might be a switch, but EPC says it's not valid and gives no PN.
So much for special order on the switch, but from what most people say it's not the switch itself, but that it's not making good contact.

Mine seems worse when it's cold.
I checked the wiring diagrams too, no switch, but does state it's a 2 wire connector.
The whole handle assembly is about $200...hopefully not needed.

Attached Thumbnails C-Coupe HATCH won't open-c230-hatch-latch.jpg  
Reply
Old Jun 28, 2009 | 03:09 AM
  #13  
C230 Sport Coup's Avatar
MBWorld Fanatic!
20 Year Member
Liked
Loved
Community Favorite
 
Joined: Jun 2002
Posts: 7,267
Likes: 170
From: So. Oregon Coast
C230 Sport Coup + 2006 W164 ML350 + 99 Ford Escort RIP
Update!
Well I finally tackled this.
Turns out there's a metal piece that makes contact with the micro switch.
I bent it a little bit so it makes better contact, but now I'm getting a constant
"trunk open" error.
I tried adjusting the hasp on the bottom of the hatch.
But still I just keep getting the error.

Anyone seen this?
What the heck tells the ECU if the hatch is opened or closed?
The trunk release has 2 connectors, one for the emergency release in the
hatch panel, and the other for the micro switch.
So, what the heck tells the computer is the hatch is open or closed?
I don't see a sensor or switch anywhere>?

BTW- the pn for the micro-switch is 2038217451.
It's #40 in the picture.

Last edited by C230 Sport Coup; Jun 28, 2009 at 03:11 AM.
Reply
Old Jun 29, 2009 | 04:23 AM
  #14  
C230 Sport Coup's Avatar
MBWorld Fanatic!
20 Year Member
Liked
Loved
Community Favorite
 
Joined: Jun 2002
Posts: 7,267
Likes: 170
From: So. Oregon Coast
C230 Sport Coup + 2006 W164 ML350 + 99 Ford Escort RIP
Same question...how does the ECU know if the hatch is closed, where's the sensor.
Reply
Old Sep 7, 2010 | 01:15 PM
  #15  
C230 Sport Coup's Avatar
MBWorld Fanatic!
20 Year Member
Liked
Loved
Community Favorite
 
Joined: Jun 2002
Posts: 7,267
Likes: 170
From: So. Oregon Coast
C230 Sport Coup + 2006 W164 ML350 + 99 Ford Escort RIP
BTW- Just an update, I fixed this long ago, I had left one cable disconnected, and that's why it thought it was not closed.
Reply
Old Sep 7, 2010 | 01:27 PM
  #16  
jcnash's Avatar
MBWorld Fanatic!
15 Year Member
Photogenic
Photoriffic
Shutterbug
 
Joined: May 2009
Posts: 1,101
Likes: 5
From: Toronto, NYC
2002 Mercedes Benz C230 Coupe
Originally Posted by C230 Sport Coup
BTW- Just an update, I fixed this long ago, I had left one cable disconnected, and that's why it thought it was not closed.
I dont have the hatch open problem., but I do have tons of squeaks and rattles from the hatch trim.

You mentioned that you will be tacking this issue as well...how did it go?
Reply
Old Sep 7, 2010 | 06:59 PM
  #17  
C230 Sport Coup's Avatar
MBWorld Fanatic!
20 Year Member
Liked
Loved
Community Favorite
 
Joined: Jun 2002
Posts: 7,267
Likes: 170
From: So. Oregon Coast
C230 Sport Coup + 2006 W164 ML350 + 99 Ford Escort RIP
Originally Posted by jcnash
I dont have the hatch open problem., but I do have tons of squeaks and rattles from the hatch trim.

You mentioned that you will be tacking this issue as well...how did it go?
Just fine.
While i had all the plastic bits off, I put thin stips of stick-on felt
on the edges of te trim pieces where they contact the other pieces, and it's very quiet.

My most annoying noise is the chrome door pins I bought,
Can't seem to get the passenger side one from making
horrendous noises, and where did I put the damn plastic ones? arg.
Reply
Old Sep 7, 2010 | 07:05 PM
  #18  
jcnash's Avatar
MBWorld Fanatic!
15 Year Member
Photogenic
Photoriffic
Shutterbug
 
Joined: May 2009
Posts: 1,101
Likes: 5
From: Toronto, NYC
2002 Mercedes Benz C230 Coupe
Originally Posted by C230 Sport Coup
Just fine.
While i had all the plastic bits off, I put thin stips of stick-on felt
on the edges of te trim pieces where they contact the other pieces, and it's very quiet.

My most annoying noise is the chrome door pins I bought,
Can't seem to get the passenger side one from making
horrendous noises, and where did I put the damn plastic ones? arg.
Nice! The rattles from the hatch trim are starting to annoy me. Need to open it up and put some felt in soon.

I also have weird rattles coming from behind the center console, door/B-pillar area.
Reply
Old Oct 28, 2010 | 03:09 PM
  #19  
C230 Sport Coup's Avatar
MBWorld Fanatic!
20 Year Member
Liked
Loved
Community Favorite
 
Joined: Jun 2002
Posts: 7,267
Likes: 170
From: So. Oregon Coast
C230 Sport Coup + 2006 W164 ML350 + 99 Ford Escort RIP
FYI- It is nearly impossible to remove the piece below the window without breaking most of the tabs. I think at the dealer, they consider it expendable, but I still have the original piece.
Reply
Old Dec 2, 2010 | 09:20 PM
  #20  
Adrian29's Avatar
Newbie
 
Joined: Sep 2008
Posts: 2
Likes: 0
C230 kompressor
Originally Posted by C230 Sport Coup
BTW- Just an update, I fixed this long ago, I had left one cable disconnected, and that's why it thought it was not closed.
First..thank you so much for the detailed instruction. Following them I managed to fix my trunk hatch and save the plastic covers.

I am getting also the "trunk is open" alarm when I place the car on drive. If I clear the signal it will come back at more then 10 miles /hours when the door auto-close feature kicks in.

If I clear it it again will stay away until next time when I start the car.

You mentioned that you have left one cable disconnected. I have check all my cables and they are all in place. Which cable are you referring to?Perhaps I didn't push it in well enough....
Reply
Old Dec 3, 2010 | 11:08 AM
  #21  
drb930's Avatar
Senior Member
15 Year Member
Photogenic
Photoriffic
 
Joined: Sep 2008
Posts: 468
Likes: 23
From: Los Angeles
2005 C230 Sport Coupe
...
Reply
Old Dec 5, 2010 | 01:11 AM
  #22  
rbuyny's Avatar
Newbie
 
Joined: Dec 2010
Posts: 1
Likes: 0
2003 C240
I am having the same problem with my wagon (2003 C240)....Can't open my hatchback!!!!
Need HELP, don't even know how to open from the inside!!!
Need car to transport baby and stroller...
Would appreciate any feedback,
Thanks
Have a great day
Reply
Old May 18, 2014 | 12:25 AM
  #23  
klausc230's Avatar
Newbie
 
Joined: May 2014
Posts: 5
Likes: 0
2003 C230 coupe
Hatchback wont open

I had the same problem on my C230. I found the switch wasn't making contact. Went to my local MB dealer in Dallas and was quoted 361.00 for the part. I passed on it and went back home to try a self repair. A rubber band wrapped around the micro switch tightened the contact up and it has worked perfectly ever since. I may need a fresh rubber band in a few years but 30 minutes to repair the problem with no part cost was not a bad deal. I know it's redneck engineering but it worked well. I hope this helps someone out.
Reply
Old May 19, 2014 | 07:22 PM
  #24  
C230 Sport Coup's Avatar
MBWorld Fanatic!
20 Year Member
Liked
Loved
Community Favorite
 
Joined: Jun 2002
Posts: 7,267
Likes: 170
From: So. Oregon Coast
C230 Sport Coup + 2006 W164 ML350 + 99 Ford Escort RIP
Just bend the metal piece that contacts the switch a tiny bit, not too much.
Reply
Old May 19, 2014 | 07:23 PM
  #25  
C230 Sport Coup's Avatar
MBWorld Fanatic!
20 Year Member
Liked
Loved
Community Favorite
 
Joined: Jun 2002
Posts: 7,267
Likes: 170
From: So. Oregon Coast
C230 Sport Coup + 2006 W164 ML350 + 99 Ford Escort RIP
If anyone reads this and insists on having a new handle assembly i have one for sale, including the switch.
Reply

Thread Tools
Search this Thread
Rate This Thread
Rate This Thread:
You have already rated this thread Rating: Thread Rating: 4 votes, 5.00 average.


All times are GMT -4. The time now is 03:15 PM.

story-0
7 Craziest Things AMG Gas Ever Built

Slideshow: Sometimes AMG builds fast sedans. Other times, it builds twin-turbo V12 land missiles and six-wheeled off-road monsters.

By Verdad Gallardo | 2026-05-26 17:59:58


VIEW MORE
story-1
New Electric Mercedes-AMG GT 4-Door Coupe Unveiled: 10 Things You Need to Know

Slideshow: Mercedes-AMG's new electric GT 4-Door Coupe trades combustion for software, synthetic noise, and more than 1,100 horsepower.

By Verdad Gallardo | 2026-05-20 20:08:15


VIEW MORE
story-2
6 Mercedes Models That Did NOT Age Well (But Are Somehow Still Cool)

Slideshow: Not every Mercedes design becomes timeless, some feel stuck in the era they came from.

By Verdad Gallardo | 2026-05-12 18:09:07


VIEW MORE
story-3
Manual Mercedes? 6 Times Sindelfingen Let Drivers Have All The Fun

Slideshow: Yes, Mercedes built manual cars, and some of them are far more interesting than you'd expect.

By Verdad Gallardo | 2026-05-02 12:36:58


VIEW MORE
story-4
Mercedes SLR McLaren 722 S Is Extremely Rare Example Modified by McLaren

Slideshow: A one-of-one U.S.-spec Mercedes-Benz SLR McLaren Roadster became even rarer after a factory-backed transformation at McLaren's headquarters.

By Verdad Gallardo | 2026-04-29 11:19:28


VIEW MORE
story-5
8 Classic Boxy Mercedes Designs That Have Aged Like Fine Wine

Slideshow: Before curves took over, Mercedes mastered the art of the straight line, and some of those shapes still look right today.

By Verdad Gallardo | 2026-04-25 12:05:49


VIEW MORE
story-6
Flawlessly Restored Mercedes 190E Evo II Heads to Auction

Slideshow: The 190E Evolution II shows how a homologation necessity became a six-figure collector icon.

By Verdad Gallardo | 2026-04-22 17:53:47


VIEW MORE
story-7
Electric Mercedes C-Class Unveiled: 11 Things You Need to Know

Slideshow: Mercedes is turning one of its core nameplates electric, and the details show just how serious this shift is.

By Verdad Gallardo | 2026-04-21 13:58:06


VIEW MORE
story-8
Mercedes EQS Gets A Major Update: Everything You Need to Know

Slideshow: Faster charging, longer range, and a controversial steer-by-wire system define the latest evolution of Mercedes-Benz EQS.

By Verdad Gallardo | 2026-04-15 10:35:34


VIEW MORE
story-9
5 Underrated Mercedes-Benz Models That Don't Get the Love They Deserve

Slideshow: These overlooked Mercedes-Benz models never got the spotlight, but they quietly delivered more than most remember.

By Verdad Gallardo | 2026-04-13 19:35:45


VIEW MORE